| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Total Violations |
3 |
Date of Inspection |
09/14/2022 |
| Risk Violations Count |
1 |
Inspection Time |
01.0 |
| Arrival Time |
10:00 |
Recommended for License |
YES |
| Travel Time |
00.2 |
Facility Closure |
NO |
|
Food Facility
2 LITTLE PIGGYS BBQ AND CATERING |
Address
33 LEGRANDE AVE |
City/State
PENNDEL, PA |
Zip Code
19047 |
Telephone
(267) 776-3310 |
Facility ID #
32F047 |
Owner
JULIET MERRIGAN |
Purpose of Inspection
Initial |
License Type
Permanent |
Risk Category
3 |
|
FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
|
|
IN=in compliance
OUT=not in compliance
N/O=not observed
N/A=not applicable
|
|
COS=corrected on-site during inspection
R=repeat violation
|
|
|
| Compliance Status |
COS |
R |
| Demonstration of Knowledge |
| 1 |
IN |
Certification by accredited program, compliance with Code, or correct responses |
|
|
| Employee Health |
| 2 |
IN |
Management awareness; policy present |
|
|
| 3 |
IN |
Proper use of reporting; restriction & exclusion |
|
|
| Good Hygienic Practices |
| 4 |
IN |
Proper eating, tasting, drinking, or tobacco use |
|
|
| 5 |
IN |
No discharge from eyes, nose, and mouth |
|
|
| Preventing Contamination by Hazards |
| 6 |
IN |
Hands clean & properly washed |
|
|
| 7 |
IN |
No bare hand contact with RTE foods or approved alternate method properly followed |
|
|
| 8 |
IN |
Adequate handwashing facilities supplied & accessible |
|
|
| Approved Source |
| 9 |
IN |
Food obtained from approved source |
|
|
| 10 |
N/O |
Food received at proper temperature |
|
|
| 11 |
IN |
Food in good condition, safe, & unadulterated |
|
|
| 12 |
N/A |
Required records available: shellstock tags, parasite destruction |
|
|
| Protection from Contamination |
| 13 |
IN |
Food separated & protected |
|
|
| 14 |
IN |
Food-contact surfaces: cleaned & sanitized |
X |
|
| 15 |
IN |
Proper disposition of returned, previously served, reconditioned, & unsafe food |
|
|
|
|
| Compliance Status |
COS |
R |
| Potentially Hazardous Food Time/Temperature |
| 16 |
N/O |
Proper cooking time & temperature |
|
|
| 17 |
N/O |
Proper reheating procedures for hot holding |
|
|
| 18 |
IN |
Proper cooling time & temperature |
|
|
| 19 |
N/O |
Proper hot holding temperature |
|
|
| 20 |
IN |
Proper cold holding temperature |
|
|
| 21 |
IN |
Proper date marking & disposition |
|
|
| 22 |
N/O |
Time as a public health control; procedures & record |
|
|
| Consumer Advisory |
| 23 |
N/A |
Consumer advisory provided for raw or undercooked foods |
|
|
| Highly Susceptible Populations |
| 24 |
N/A |
Pasteurized foods used; prohibited foods not offered |
|
|
| Chemical |
| 25 |
N/A |
Food additives: approved & properly used |
|
|
| 26 |
IN |
Toxic substances properly identified, stored & used |
|
|
| Conformance with Approved Procedure |
| 27 |
IN |
Compliance with variance, specialized process, & HACCP plan |
|
|
Risk factors are improper practices or procedures identified as the most
prevalent contributing factors of foodborne illness or injury. Public Health
Interventions are control measures to prevent foodborne illness or injury. * - Critical Item Requiring Immediate Action
|
|
| GOOD RETAIL PRACTICES |
Good Retail Practices are preventative measures to control the addition of pathogens,
chemicals, and physical objects into foods.
|
|
| Compliance Status |
COS |
R |
| Safe Food and Water |
| 28 |
IN |
Pasteurized eggs used where required |
|
|
| 29 |
IN |
Water & ice from approved source |
|
|
| 30 |
IN |
Variance obtained for specialized processing methods |
|
|
| Food Temperature Control |
| 31 |
IN |
Proper cooling methods used; adequate equipment for temperature control |
|
|
| 32 |
IN |
Plant food properly cooked for hot holding |
|
|
| 33 |
IN |
Approved thawing methods used |
|
|
| 34 |
IN |
Thermometer provided & accurate |
|
|
| 35 |
IN |
Food properly labeled; original container |
|
|
| Prevention of Food Contamination |
| 36 |
IN |
Insects, rodents & animals not present; no unauthorized persons |
|
|
| 37 |
IN |
Contamination prevented during food preparation, storage & display |
|
|
| 38 |
IN |
Personal cleanliness |
|
|
| 39 |
IN |
Wiping cloths: properly used & stored |
|
|
| 40 |
IN |
Washing fruit & vegetables |
|
|
|
|
| Compliance Status |
COS |
R |
| Proper Use of Utensils |
| 41 |
IN |
In-use utensils: properly stored |
|
|
| 42 |
IN |
Utensils, equipment & linens: properly stored, dried & handled |
|
|
| 43 |
IN |
Single-use & single-service articles: properly stored & used |
|
|
| 44 |
IN |
Gloves used properly |
|
|
| Utensils, Equipment and Vending |
| 45 |
OUT |
Food & non-food contact surfaces cleanable, properly designed, constructed, & used |
|
X |
| 46 |
IN |
Warewashing facilities: installed, maintained, & used; test strips |
|
|
| 47 |
IN |
Non-food contact surfaces clean |
|
|
| Physical Facilities |
| 48 |
IN |
Hot & cold water available; adequate pressure |
X |
|
| 49 |
IN |
Plumbing installed; proper backflow devices |
|
|
| 50 |
IN |
Sewage & waste water properly disposed |
|
|
| 51 |
IN |
Toilet facilities: properly constructed, supplied, & cleaned |
|
|
| 52 |
IN |
Garbage & refuse properly disposed; facilities maintained |
|
|
| 53 |
IN |
Physical facilities installed, maintained, & clean |
|
|
| 54 |
IN |
Adequate ventilation & lighting; designated areas used |
|
|
|
|
|
|
|
|
| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Date of Inspection |
09/14/2022 |
| Arrival Time |
10:00 |
| Recommended for License |
YES |
| Facility Closure |
NO |
|
Facility
2 Little Piggys BBQ and Catering |
Address
33 LEGRANDE AVE |
City/State
PENNDEL, PA |
Zip Code
19047 |
Telephone
(267) 776-3310 |
Facility ID #
32F047 |
Owner
Juliet Merrigan |
Purpose of Inspection
Initial |
License Type
Permanent |
Risk Category
3 |
|
|
TEMPERATURE OBSERVATIONS
|
| Item/Location |
Temp |
Item/Location |
Temp |
Item/Location |
Temp |
| Ambient/Walk-In Cooler |
35 ° F |
Crab meat/Walk-In Cooler |
34 ° F |
Ambient/Galaxy chest freezer |
7 ° F |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| OBSERVATIONS AND CORRECTIVE ACTIONS |
Item
Number |
Violations cited in this report must be corrected within the time frames below.
|
|
*14
|
*Low-heat mechanical dishwasher not providing adequate sanitizing solution concentration. Approximately 10 ppm of Chlorine-based sanitizer was measured through several cycles of unit.
Sanitizer container was replaced with new.
Unit was cycled and 100 ppm Chlorine was then measured. Corrected On-Site. New Violation.
|
|
45
|
Facility has placed a heavy mat above the section of damaged floor in the walk-in cooler.
Per owner, a plate will be added to repair affected area. Repeat Violation.
|
|
48
|
*Hot water temperature at the low-heat mechanical dishwasher was measured at 100°F - 108°F.
Hot water heater was adjusted during inspection.
Water temperature at the mechanical dishwasher was raised to 120°F for wash and rinse. Corrected On-Site. New Violation.
|
|
|
|
|
|
|
|
General Remarks
|
Food license renewal application and fee (check #1151, $515) received at time of inspection.
Facility approved for food license renewal.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|